Airheads Beemer Club - Classifieds


FOR SALE: 1984 BMW R100RT ‘FINAL EDITION’ Asking $5000.00 – MUST SELL ........... A great ride for the serious “AIRHEAD” aficionado. Purchased with 30,000 miles on the odometer. Ridden a bit more than 1000 miles since restoration. The bike did not show any signs of abuse at purchase, only neglect........... Purchased June 2007 for $3000.00. More than $2000.00 invested in parts and subcontracted services............ Approximately 600 hours of research/study and wrench twisting to restore the bike to its current condition. Most of the paint is original........... A retired toolmaker/machine builder did the restoration process............ A list of the parts and services (with pricing) used in the restoration is shown below. Suppliers are listed in hidden columns. Mileage Work Performed Cost 30000 Glass bead wheels $50.00 30000 Clear Powder Coat Wheels $200.00 30000 Remove Tires & Bearings $47.00 30000 Metzler Lasertech Tires $253.72 30000 (2) Tubes & (2) Spares $38.18 30000 Mount and Balance Wheels $40.50 30000 Front Wheel Bearings $39.66 30000 Stainless steel header pipes and crossover tubes $265.00 30000 Rear Wheel Bearings $39.66 30000 Valve Cover Gaskets $21.95 30000 Diode Board Kit $96.65 30000 Dust Cover $31.00 30000 Classic Boxer Charging Manual $26.50 30000 Wheel Bearing Seals $26.95 30000 Fairing Gasket Set $57.85 30000 Locktite Prism Glue for Fairing Gaskets $18.32 30000 Accessory Power Socket, Oil Filter Kit, Air Filter, Fuel Filters (2), Halogen Bulb $112.73 30000 Voltage Regulator, Diode Board Solid Mount Kit, $58.65 30000 Carb Cleaner $6.39 30000 Spark Plugs, Fork Oil, Gear Oil (2), Brake Fluid, Castrol 20W50, Electro -Seal Sealent $89.65 30000 Misc. Seals $20.95 30000 White Lithium Grease, Molycoat Cartridge, Grease Gun, Antiseize Compound, Hose Clamps for Fuel Lines, Fuel Line, Hose Clamps for Exhaust $98.89 30000 Wheel Bearing Greaser $24.00 30000 Oil Pressure Switch $21.98 30000 Kano Kroil Penetrating Oill $21.92 30000 Airhead Exhaust Nut Wrench $36.46 30000 Wheel Spacers and Misc. Gaskets $51.55 30000 Brake Light, Clutch Cable, Collar, Boot, Grommet $57.85 30000 Odyssey Dry Cell Battery $120.00 30000 Misc. Paint, Lubricants, Fluids, Cleaners $100.00 TOTAL COST $2,073.96........... Plus I probably missed a few hundred dollars in misc. parts and service.......... In addition to parts and subcontracted services, the following work has been done during the restoration process: • Wheels removed, glass beaded & clear powder coated • Bike was stripped down to the frame, most of which was repainted • Installed and balanced new Metzler Lasertech tires. • Installed and adjusted preload on front and rear wheel bearings • All component parts were cleaned, repainted and waxed during reassembly • Charging system rebuilt/rewired – Omega diode board with solid mounts • New heavy duty voltage regulator installed • Accessory 12V socket installed • New Oddyssey Extreme dry cell battery installed. Can be stored for two years on a full charge without failing. • Valves adjusted and new valve cover gaskets installed • Carburetors cleaned and adjusted • New spark plugs installed • Complete tune up sequence performed from plug installation to carburetor balancing • Replaced fuel lines and added aftermarket filters • Gas tank epoxy coated inside – tank was flushed, cleaned and new internal filters installed • Transmission and clutch splines cleaned and lubricated • Brake lines drained, flushed and refilled with new fluid – brake pads are 80% • Oil and filter changed • Transmission, driveshaft & final drive fluids replaced • Swing arm bearings removed, cleaned, greased, replaced and adjusted • Clutch adjusted........... Following is a list of special tools (purchased and custom built) and documentation that go with the bike: • Custom made spacers (2) for setting the preload on front and rear wheel bearings • Finned exhaust nut wrench • Classic Boxer Charging Manual by Rick Jones • Home built manometer for balancing carbs • Manuals and custom instruction folder for mechanical troubleshooting/repair/adjustment of major components. Explosion drawings, torque chart and part lists included (with dirty finger prints) • Maintenance schedule • 2008 BMW owners Anonymous Book.......... Following is a list of spare parts and materials that go with the bike: • Spare halogen headlight bulb • Wheel preload shims • Wheel bearing lubrication tool • Spring balance for adjusting wheel bearing preload • Misc. bulbs • Cotton dust cover • Replacement clutch cable • Fork oil • Cleaners, wax. Lubricants and Misc............ Following is a list of items that need done to make the bike 100% mechanically & electrically complete (I ran out of time): • Oil change (last changed fall of 2007 prior to winter storage) • Loosen all fairing screws, realign components and retighten – it’s tweaked out of square a bit. • Front turn signals do not work – repair • Horns do not work – repair • Replace front fork oil – in stock • Redo tune up to improve engine response Exceptions: • Minor damage to fairing and left side mirror • Mismatched paint color on one new battery cover One change that I had planned was to remove the tires/tubes and spotface the inside of the rim at the valve hole. Replace the tires without tubes to make roadside repairs possible. I researched this thoroughly and it can be done safely with the BMW snowflake wheels.

Phone: 651.592.1521

Your Name
Your Email adress
Your message

Mambo-êîìïîíåíò Classifieds âåðñèÿ 1.4
Copyright by POSLuH d.o.o, Gorsk.net Studio

comments

There are no comments yet - feel free to add one using the form below...

Page 1 of 0 ( 0 comments )

You are not authorized to leave comments - please login.

Latest Classified

Nice 1981 R100 in Southern California

Advertisements

Bing Carburetors: Home for Airhead carburetors. The Bing Agency is the repair specialists and source for all Bing components. Call 800-309-2464 for orders or 620-767-7844 for tech support.

Airheads Beemer Club; PO Box 178913; San Diego, CA 92177
Copyright © 2006 Airheads Beemer Club. All Rights Reserved.
The Airheads logo and airheads.org domain are registered trademarks of the Airheads Beemer Club.
Disclaimer

BMW MOA club # 214