Wherle Electronic Voltage Regulator

This modification is for the plastic case electronic voltage regulator that Wherle made, with its name on the case. I have only modified a few of these.  IT IS POSSIBLE THAT YOURS MIGHT LOOK DIFFERENT INSIDE, as other versions could have been made. 

This modification will increase the charge voltage to better charge the battery and give longer life. This will be useful in instances where the voltage at the battery terminals is found to be at or below 13.9, at approximately 70°F at the regulator. This modification will ensure better battery charging, and longer battery life, especially for in-town commuters. This modification essentially turns your voltage regulator into the pricier BMW-sold high voltage Authorities (Police) regulator, very cheaply. TWO methods are described, so that at least one of the parts needed will be available locally.  All Wehrle regulators are not the same.  Be sure yours is the same as the one described here, before modifying it.

Cost: I will assume you have the tools, and will do the labor yourself. The parts cost will be from 10 cents to $3.00, depending on what part(s) you purchase.

You must be a member to view complete articles on this website. If you are already a member, you can log in here. If you aren’t a member yet, you can purchase a membership here.

Continue readingMore Tag

Testing Voltage Regulators

If you have a charging problem, you may want to find out if the VR (Voltage Regulator) is the problem.  A faulty VR can cause various problems, the most common are no charging or too high a voltage during charging. NOTE that the stock factory VR internal setting is such that the battery terminal voltage is typically 13.8 volts during cruising (the higher voltage Authorities…Police…regulators are about 14.2).  The 13.8v is a reasonable compromise for water use on flooded fillable batteries, but really too low for best battery life, particularly on AGM/VRLA batteries.

There are TWO very easy ways to test a voltage regulator that do NOT involve the technical methods in the rest of this article. These two methods are:

1. Substituting a known good voltage regulator (any 1970+ BMW airhead regulator, or any three terminal automotive regulator that fits the airhead plug).  If whatever the problem was now disappears, then the VR was faulty.

You must be a member to view complete articles on this website. If you are already a member, you can log in here. If you aren’t a member yet, you can purchase a membership here.

Continue readingMore Tag

Bosch Metal Can Mechanical Voltage Regulator, Cleaning & Adjusting

The first part of this article covers the basics for this 12 volt VR unit, as used on BMW Airhead motorcycles before BMW changed to electronic ignition in 1981. This article applies ONLY to the mechanical voltage regulators. These were used on the Airheads from 1970 to ~1980.

At the end of this article are some addendums. #1 is a description and schematic diagram.  #2 is for the BMW /2 (6 volt) motorcycle’s VR. I suggest you DO read that section, even if you do not have a /2, as it has a slightly different way of explaining the servicing (included in this article).

Voltage regulators, both mechanical & electronic, in metal cans, were installed as stock items on early BMW Airhead motorcycles. There is nothing wrong with the mechanical type for the early BMW Airhead Motorcycles, except that mechanical types DO wear, over time & mileage. In an emergency an old mechanical VR might do OK in any Airhead model, although the electronic ignition could possibly (not necessarily will) miss-fire occasionaly with a mechanical regulator. Mechanical regulators wear mostly from their constant points vibrating/buzzing/arcing. Electronic regulators will substitute for the mechanical regulator on any Airhead model, directly, with no problems. All the mechanical regulators were inside of tall metal cans. Later voltage regulators were electronic; but the early electronics versions ALSO were in metal cans, but they were shorter in height.  The next series were in smallish plastic cases, often with black bodies and red tops. There are aftermarket electronic regulators available, some are adjustable, & most 3 male spades type of voltage regulators from European cars (that the Airhead cable plug fits into) could also be substituted. The stock METAL can electronic regulators are also adjustable, there is an article on this Airheads website about how to go about that, since the adjustment is sealed. There is also a bit more of an article here:  http://bmwmotorcycletech.info/boschelreg.htm

You must be a member to view complete articles on this website. If you are already a member, you can log in here. If you aren’t a member yet, you can purchase a membership here.

Continue readingMore Tag
Scroll to top